Archive for the ‘Volkswagen’

Volkswagen Passat Double-Din (DD) Radio MFD Installation

June 18, 2011 Category: Volkswagen

Volkswagen Passat Double-Din (DD) Radio MFD Installation

The DIY project installation for all Passats (Sedan or Avant) with Double-Din radio ONLY (”Premuim 6″ in USA with or without Monsoon system, or “Delta 6″ in Europe). This Volkswagen Passat MFD installation contains only 12 step to follow. Step 9 MFD installation : After you are done with the wires, you can put the [...]

VW T5 Transporter Intercooler Installation

June 18, 2011 Category: Volkswagen

VW T5 Transporter Intercooler Installation

VW T5 transporter front mounted intercooler installation. Step by step instruction for intercooler installation complete with picture explanation. The mounting step : 1. Position the vehicle on level ground with the front wheels facing forward, then undo the two T25 screws on the front edge of each wheel arch, and the single screw holding the [...]

Volkswagen Engine, Removing and Installing

June 04, 2011 Category: Volkswagen

Volkswagen Engine, Removing and Installing

This document contains all information on removing and installing Volkswagen engine with manual and automatic transmission. Here you can find the tools and equipment on removing ang installing engine, Engine mounting on engine stand, Remove axle shafts, engine installing, Assembly mounts torque values, Tightening torques with bolts oiled, Vehicles with A/C, additional information and removal [...]

Universal IMMO VAG Immobilizer/Emulator Manual

May 26, 2011 Category: Audi, Volkswagen

Universal IMMO VAG Immobilizer/Emulator Manual

From year 1995 in Audi-VW (VAG) cars is used engine immobilizer. The VAG group immobilizer system consists of an immobilizer ECU which controls the recognition of keys and the Engine Management ECU system. Immobilizer is activated when the ignition key is removed and, together with the engine control unit, largely preventsm unauthorized starting of the [...]

Volkswagen 123 Ignition Installation Instructions

March 18, 2011 Category: Volkswagen

Volkswagen 123 Ignition Installation Instructions

Volkswagen 123 Ignition Installation Instructions. The installation type : 123\VW-R & 123\VW-R-V, for : VW types 1,2&3,181,Porsche 356, Porsche 912 & tuning engines for 6 or 12 Volt cars, negative earth only. STEP 1: Find the static timing point. On the old distributor, note the position of the ignition wire to the number one cylinder. [...]